Sample Preparation Typically, titanium and zirconium samples are chemically etched to remove surface contamination when oxygen and nitrogen are determined. However, etching can introduce hydrogen into the sample. ASTM method E 1409 "Determination of Oxygen and Nitrogen in Titanium

力可ONH836氧氮氫分析儀 特點和優勢 國際**的非色散紅外及熱導檢測器 ，無移動部件，不需要手動調整 采用三個**的紅外器檢測氧含量，同時檢測CO和CO2，然后在轉化為CO2集中檢測，原理上是**完善的，所以不僅可以保證中間量程的測量精度，在**含量和高含量的檢測范圍內同樣可以滿足精度要求 高性能的紅外檢測器配置***恒溫絕熱技術，消除了外界環境溫度的干擾 長壽命的紅外發射光源和無漂移的電路設計保證檢測器的長期穩定性 力可**的動態流量補償控制DFC系統，保證了流量系統的完善，可以精確控制整個氣路中的流量，保持流量恒定**改善了材料中氮分析的準確度 ...

Procedure - Solid Samples Prepare the instrument as outlined in the operator's instruction manual. Determine the instrument blank. Login a minimum of 3 Blank replicates. Press the Analyze button on the instrument screen. After a short delay, the loading head slid

company profile Shanghai Uzong Industrial Co., Ltd. (hereinafter referred to as UZONGLAB?) is a high-tech company that provides integrated solutions for intelligent laboratories, mainly serving the Chinese market and countries along the “Belt and Road”. It has three business divisions and one T...

Procedure – Powder/Chip Samples Prepare the instrument as outlined in the operator's instruction manual. Determine the instrument blank. Login a minimum of three Blank reps. Press the Analyze button on the instrument screen. After a short delay, the loading head slide-block wi...

氧氮氫分析儀是快速、準確分析氧、氮、氫元素的、高性能儀器，整機采用模塊化、一體化設計，即主機由可靠的脈沖電極爐、高靈敏高精度的檢測系統、布局合理和氣密性好的氣路系統、可靠耐用的電源系統、穩定的電路系統、高校節能的水循環散熱系統等六個**的硬件模塊單元組成。 氧氮氫分析儀的測量原理： 測量范圍非常***。分析樣品時，樣品被稱重后放到樣品端口中，然后用載氣進行沖洗，防止大氣（含氧氣和氮氣）進入到爐子系統中。 石墨坩堝在脈沖爐中脫氣，以盡量減少自帶的污染。經過穩定階段后樣品落入坩堝中并熔融。樣品中的氧與石墨坩堝中的碳反應生成一氧化碳。氮和氫以單質的形式釋放。載氣和樣品氣體通過粉...

Oxygen, Nitrogen, and Hydrogen in Refractory Metals Summary Titanium is a metal that can be combined with elements such as aluminum, vanadium, molybdenum, and tin to produce high-strength, lowdensity, and corrosion-resistant alloys. Titanium alloys are used by the military, medical dev

氧氮氫分析儀的常見故障及解決方法 儀器啟動時顯示。沒有水流。系統分析電流切斷，分析停止。這是水流探測器不正常，水泵不工作，管道堵塞。將儀器的右面板取下，觀察水流探測器，用手擠壓補水塑料水瓶，發現水流正常，顯示正常，證明水流探測器正常，管道暢通。啟動循環水泵，但分析儀顯示沒有水流，此時可判定水泵不正常。打開水泵轉子密封口，啟動泵發現電機正常運轉，此時關閉進水，拆下水泵，發現葉輪脫落。經了解，判定是由于外部冷卻水停水，儀器內循環水溫過高（水溫應≤70℃），致使葉輪（葉輪材料PVC）熱脹并脫軸。用粘合劑粘合葉輪后再粘于葉輪軸上，待粘合劑凝固后試車，儀器運行正常。 試樣加載過程中完全密閉，消...

company profile Shanghai Uzong Industrial Co., Ltd. (hereinafter referred to as UZONGLAB?) is a high-tech company that provides integrated solutions for intelligent laboratories, mainly serving the Chinese market and countries along the “Belt and Road”. It has three business divisions and one T...

Procedure – Powder/Chip Samples Determine the instrument blank. Press the Analyze button on the instrument screen, the lower electrode will close and the analysis sequence will start and end automatically. Repeat steps 2b through 2g a minimum of three times. Set the blank f...

Summary The determination of the amount of oxygen, nitrogen, and hydrogen in iron, steel, nickel-, and cobalt-base alloys represents some of the most important quality metrics for these materials. Oxygen is used to create steel from pig iron by removing excess carbon. Oxygen content must be

736 Series: Oxygen/Nitrogen by Inert Gas Fusion The 736 family of Elemental Analyzers is designed for routine measurement of oxygen and nitrogen content of inorganic materials, ferrous and nonferrous alloys, andrefractory materials using the inert gas fusion technique. These instrumen

Procedure – Powder/Chip Samples Instrument calibration/drift correction. Add approximately 0.05 g of *** Graphite Powder to a***Graphite Crucible. Firmly place the crucible on the lower electrode tip or appropriate autoloader position. Press the Analyze button on t...

氧氮氫分析儀的優點 采用惰氣熔融技術，同時測定氧、氮和氫元素含量 新設計封閉氣路系統，優化氣路循環，使氧氮氫測量更準確 可采用更廉價的氬氣作為載氣 催化爐溫度可調，使氧的測量更加準確 氣路系統都采用電磁閥控制，新增分段式漏氣檢測 水冷樣品加樣端口，有效隔絕雜質氣體侵入 儀器配置和氧、氮、氫測量范圍可靈活選擇 新設計的高靈敏度紅外檢測池和熱導池，有極低的檢出限 分析時間短 脈沖爐功率高達8.5kw，溫度3000℃ 顆粒狀樣品無需膠囊包裹，使用經濟實惠 ...

ONH836系列：氧氮氫分析儀（熔融法） 軟件特點和優勢 Cornerstone氧氮氫分析軟件分成4個主要部分：分析、診斷、設定、儀器，界面可以快速導航和組織。工具條、滑動條和下拉式菜單簡化了校正和數據處理的參數設定。分析軟件同時包括實時的環境參數的監測，提供完整的系統圖表模擬。高級診斷程序包括全數字化的在線操作手冊、維護模擬演示、圖片說明等提供快速指導。Cornerstone氧氮氫分析軟件同時支持***的數據文檔格式和可變的報告格式。 采用三個**的紅外器檢測氧含量，同時檢測CO和CO2，然后在轉化為CO2集中檢測。美國分析儀廠家直銷 Procedure - Solid S...

氧氮氫分析儀的使用注意事項： 1 、氧氮氫分析儀在初次啟用前，應該對連接點、焊點、閥門等進行檢漏，以確?？諝庵械难醪粫礉B進入管道及儀器內部，造成測量數值偏高。 2、再次使用儀器前，要進行管道系統凈化，將漏入的空氣除干凈，同時確保連接取樣管路時沒有漏入空氣。 3、樣氣中氧含量的變化會受管道材質及表面粗糙度影響，因此一般連接管路選用銅管或拋光過的不銹鋼管，而不用塑料管、橡膠管等。 4、微量元素分析時，要避免各種管件、閥門、表頭等死角對樣氣造成污染，因此必須盡可能的簡化氣路系統，連接件死角要小，以防止溶解氧逸出造成污染，使用水封、油封及臘封等設備，才能較好的確保數據的。...

氧氮氫分析儀 氧氮氫分析儀是一種用于材料科學領域的儀器，于2016年03月09日啟用。 技術指標 測量范圍： ON 低氧0.0－300ppm OH 低氧0.0－300ppm 高氧0.0－2% 高氧0.0－2% 低氮0.0―300ppm 低氫0.0－50ppm 高氮0.0－2% 高氫0.0－1000ppm 靈敏度： 氧0.01ppm；氮0.1ppm；氫0.01ppm。 主要功能 該儀器配置有16位微處理器和兩個**的分別檢測高氧和低氧的 紅外檢測池。氮和氫通過雙重范圍的熱導檢測池測量。分析過程中可自動實現從 低范圍到高范圍的切換。樣品在高功率脈沖爐的石墨坩堝中加...

Procedure – Powder/Chip Samples Determine the instrument blank. Press the Analyze button on the instrument screen, the lower electrode will close and the analysis sequence will start and end automatically. Repeat steps 2b through 2g a minimum of three times. Set the blank f...

Instrument Highlights and Features Optional Features Optional boom-mounted touch-screen interface package (M) promotes an ergonomic workspace Optional Performance Package (P) adds a three-stage carrier gas purification system, and a dual-loop gas dose module Optional Dual Cooling P

Procedure – Powder/Chip Samples Prepare the instrument as outlined in the operator's instruction manual. Determine the instrument blank. Login a minimum of three Blank reps. Press the Analyze button on the instrument screen. After a short delay, the loading head slide-block wi...

氧氮氫分析儀的優點 采用惰氣熔融技術，同時測定氧、氮和氫元素含量 新設計封閉氣路系統，優化氣路循環，使氧氮氫測量更準確 可采用更廉價的氬氣作為載氣 催化爐溫度可調，使氧的測量更加準確 氣路系統都采用電磁閥控制，新增分段式漏氣檢測 水冷樣品加樣端口，有效隔絕雜質氣體侵入 儀器配置和氧、氮、氫測量范圍可靈活選擇 新設計的高靈敏度紅外檢測池和熱導池，有極低的檢出限 分析時間短 脈沖爐功率高達8.5kw，溫度3000℃ 顆粒狀樣品無需膠囊包裹，使用經濟實惠 ...

力可ONH836氧氮氫分析儀 特征 穩固的爐頭試樣加載結構 試樣加載過程中完全密閉，消除大氣的中可能帶來的雜質的污染； 簡化日常分析所需的爐頭進樣部分機械維護工作。 可選的自動功能 上下電極自動清掃裝置； 20位試樣及坩堝自動進樣裝置。 附加功能及優點 可選六軸可旋轉觸摸屏幕，增強了操作的工效和直觀性； 可選具有壓力補償和溫度控制性能的標氣檢測氣路； 新型氣路管道減少氣路連接閥，使得漏氣，斷路故障更少； 配置SmartLine Remote遠程診斷功能。 國際**的非色散紅外及熱導檢測器 ，無移動部件，不需要手...

Procedure – Powder/Chip Samples Instrument calibration/drift correction. Add approximately 0.05 g of *** Graphite Powder to a***Graphite Crucible. Firmly place the crucible on the lower electrode tip or appropriate autoloader position. Press the Analyze button on t...

Software Features & Benefits Cornerstone brand software is divided into four main sections—Analysis, Diagnostics, Settings, and Instrument—for simplified navigation and organization. Toolbars, sliders, and drop-down menus makeit easy to set parameters for calibration and data processing. The so...

User-Friendly Brand Software Cornerstone LECO's exclusive brand software enables the user to have complete access to analysis Cornerstone control, method settings, diagnostics, reporting, and more in a highly organized and immersive environment. Designed through a collaboration of customer feed

Procedure - Solid Samples： --Instrument calibration/drift correction. Place the nickel basket containing the calibration/drift standard into the open port at the top of the loading head. Press the Analyze button on the instrument screen again, the loading head slide-block will c...

Procedure – Powder/Chip Samples Prepare the instrument as outlined in the operator's instruction manual. Determine the instrument blank. Login a minimum of three Blank reps. Press the Analyze button on the instrument screen. After a short delay, the loading head slide-block wi...

Software Features & Benefits Cornerstone brand software is divided into four main sections—Analysis, Diagnostics, Settings, and Instrument—for simplified navigation and organization. Toolbars, sliders, and drop-down menus makeit easy to set parameters for calibration and data processing. The so...

美國LECO力可氧氮氫分析儀ONH836（氧氮氫聯測儀）系列硬件部分 特點和優勢 1、爐頭區域LED照明系統 2、爐頭快速拆裝的粉塵過濾裝置 3、裝有自動旁路閥的可快速拆裝氧水捕集裝置 4、**的動態流量補償（DFC）保證熱導池氣體流量、壓力恒定 5、改進的紅外檢測池技術 新紅外池的恒溫絕熱技術消除了外界環境溫度的干擾 長壽命的紅外發射光源和無漂移的電路設計保證紅外檢測池的長期穩定 氧高低雙量程采用3個碳紅外檢測器，同時檢測一氧化碳和二氧化碳，保證準確...

Instrument Highlights and Features Optional Features Optional boom-mounted touch-screen interface package (M) promotes an ergonomic workspace Optional Performance Package (P) adds a three-stage carrier gas purification system, and a dual-loop gas dose module Optional Dual Cooling P